A L PROT T E N C E TI M O N N O A R G I E V N N C E Y ENVIRONMENTAL PROTECTION AGENCY An Ghníomhaireacht um Chaomhnú Comhshaoil LANDFILL MANUALS LANDFILL SITE DESIGN Environmental Protection Agency Establishment The Environmental Protection Agency Act, - preparation and implementation of a 1992, was enacted on 23 April, 1992, and national hydrometric programme for the under this legislation the Agency was collection, analysis and publication of formally established on 26 July, 1993. information on the levels, volumes and flows of water in rivers, lakes and Responsibilities groundwaters; and The Agency has a wide range of statutory duties and powers under the Act. The main - generally overseeing the performance by responsibilities of the Agency include the local authorities of their statutory following: environmental protection functions. - the licensing and regulation of Status large/complex industrial and other The Agency is an independent public body. processes with significant polluting Its sponsor in Government is the potential, on the basis of integrated Department of the Environment and Local pollution control (IPC) and the Government. Independence is assured application of best available technologies through the selection procedures for the for this purpose; Director General and Directors and the freedom, as provided in the legislation, to - the monitoring of environmental quality, act on its own initiative. The assignment, including the establishment of databases under the legislation, of direct responsibility to which the public will have access, for a wide range of functions underpins this and the publication of periodic reports independence. Under the legislation, it is a on the state of the environment; specific offence to attempt to influence the Agency, or anyone acting on its behalf, in - advising public authorities in respect of an improper manner. environmental functions and assisting local authorities in the performance of Organisation their environmental protection functions; The Agency’s headquarters is located in Wexford and it operates five regional - the promotion of environmentally sound inspectorates, located in Dublin, Cork, practices through, for example, the Kilkenny, Castlebar and Monaghan. encouragement of the use of environmental audits, the setting of Management environmental quality objectives and the The Agency is managed by a full-time issuing of codes of practice on matters Executive Board consisting of a Director affecting the environment; General and four Directors. The Executive Board is appointed by the Government - the promotion and co-ordination of following detailed procedures laid down in environmental research; the Act. - the licensing and regulation of all Advisory Committee significant waste disposal and recovery The Agency is assisted by an Advisory activities, including landfills and the Committee of twelve members. The preparation and periodic updating of a members are appointed by the Minister for national hazardous waste management the Environment and Local Government plan for implementation by other bodies; and are selected mainly from those nominated by organisations with an interest - implementing a system of permitting for in environmental and developmental the control of VOC emissions resulting matters. The Committee has been given a from the storage of significant quantities wide range of advisory functions under the of petrol at terminals; Act, both in relation to the Agency and to the Minister. - implementing and enforcing the GMO Regulations for the contained use and deliberate release of GMOs into the environment; LANDFILL MANUALS LANDFILL SITE DESIGN Environmental Protection Agency An Ghníomhaireacht um Chaomhnú Comhshaoil P.O. Box 3000, Johnstown Castle Estate, Co. Wexford, Ireland. Telephone : +353-53-60600 Fax : +353-53-60699 e-mail: [email protected] Website: www.epa.ie © Environmental Protection Agency 2000 All or parts of this publication may be reproduced without further permission,provided the source is acknowledged. Although every effort has been made to ensure the accuracy of the material contained in this publication,complete accuracy cannot be guaranteed. Neither the Environmental Protection Agency nor the authors accept any responsibility whatsoever for loss or damage occasioned or claimed to have been occasioned,in part or in full,as a consequence of any person acting,or refraining from acting,as a result of a matter contained in this publication. All or part of this publication may be reproduced without further permission, provided the source is acknowledged. LANDFILL MANUALS LANDFILL SITE DESIGN Published by the Environmental Protection Agency,Ireland. The Agency personnel involved in the preparation of this manual were Mr. Peter Carey (principal author),Mr. Gerry Carty (editor),Dr. Brian Donlon, Mr. Donal Howley,and Dr. Ted Nealon. ISBN 1 84095 026 9 Price Ir£15.00 12/00/750 €19.05 CONTENTS i TABLE OF CONTENTS LIST OF FIGURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .v LIST OF TABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .vi ACKNOWLEDGEMENTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .vii PREFACE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .ix LIST OF ABBREVIATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .x CHAPTER 1 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 1.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 1.2 Waste Policy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 1.3 Landfill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 1.4 Landfill Site Design . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 CHAPTER 2 DESIGN OBJECTIVES AND CONSIDERATIONS . . . . . . . . . . . . . . . . . . . . . . . . . .3 2.1 Design Objectives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 2.2 Design Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 2.3 Design Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 CHAPTER 3 SITE DEVELOPMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 3.1 Site Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 3.2 Site Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 3.3 Materials Requirement and Balance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 3.4 Phasing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 3.5 Cells . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 3.6 Bunding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7 3.7 Cover Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 3.8 Landscaping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 CHAPTER 4 SITE INFRASTRUCTURE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 4.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 4.2 Access and Traffic Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10 4.3 Site Accommodation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 4.4 Weighbridges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 4.5 Wheel Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 4.6 Site Services . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 4.7 Civic Waste Facilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 4.8 Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 CHAPTER 5 GROUNDWATER AND SURFACE WATER MANAGEMENT . . . . . . . . . . . . . . . .18 5.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 5.2 Groundwater Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 5.2.1 A Strategy for the Protection of Groundwater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 5.2.2 Groundwater Directive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 5.2.3 Groundwater Control Measures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18 5.3 Surface Water Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 5.3.1 Surface Water Collection System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 5.4 Groundwater / Surface water Monitoring Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23 CHAPTER 6 LINING SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 6.1 Functions of a Lining System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 ii LANDFILLMANUALS 6.2 Requirements of Liner Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 6.2.1 Hazardous Waste Landfill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 6.2.2 Non-hazardous Biodegradable Waste Landfill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26 6.2.3 Inert Waste Landfill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26 6.3 Natural Clay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 6.3.1 Design Parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 6.3.2 Soil Classification Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 6.3.3 Stress Deformation Behaviour . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 6.3.4 Hydraulic Conductivity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 6.3.5 Construction Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30 6.3.6 Quality Assurance Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 6.4Bentonite Enhanced Soils (BES) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33 6.5 Geosynthetic Clay Liners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35 6.6 Geomembranes (Flexible Membrane Liners) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36 6.6.1 Geomembrane Selection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36 6.6.2 Geomembrane Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .36 6.6.3 Geomembrane Process - Raw Material to Landfill System and Installation Component . . .37 6.7 Geomembrane Leak Location Surveys (GLLS) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40 6.8 Field Trials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40 CHAPTER 7 LEACHATE MANAGEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 7.1 Leachate Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 7.1.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 7.1.2 Main Constituents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 7.1.3 Significance of Constituents of Leachate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45 7.2 Leachate Volumes and Quality . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49 7.2.1 Water Balance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49 7.2.2 Controlling Leachate Production . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52 7.3 Leachate Collection and Removal System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52 7.3.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .52 7.3.2 Design Features and Recommended Minimum Standards . . . . . . . . . . . . . . . . . . . . . . . . .54 7.3.3 Sources of Clogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55 7.3.4 Preventative Measures to Reduce Clogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56 7.3.5 Leachate Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56 7.3.6 Monitoring of Leachate in Landfill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 7.4Leachate Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 7.5 Recirculation of Leachate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 CHAPTER 8 LEACHATE TREATMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63 8.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63 8.2 Physical - Chemical Pretreatment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63 8.2.1 Air Stripping of Methane . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63 8.2.2 Air Stripping of Ammonia . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .63 8.2.3 Precipitants / Flocculants . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64 8.3Biological Treatment of Leachate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65 8.3.1 Activated Sludge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65 8.3.2 Sequencing Batch Reactors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66 8.3.3 Aeration Lagoons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66 8.3.4 Rotating Biological Contactors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67 8.3.5 Combined Leachate and Urban Wastewater Treatment . . . . . . . . . . . . . . . . . . . . . . . . . . .68 8.3.6 Anaerobic Treatment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68 8.3.7 Biological Nitrogen Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68 CONTENTS iii 8.4 Physical-Chemical / Biological Treatment of Leachate . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69 8.4.1 Membrane Bioreactor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69 8.4.2 Powdered Activated Carbon (Biological) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 8.4.3 Filtration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 8.4.4 Other Treatment Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 8.5 Advanced Treatment methods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 8.5.1 Activated Carbon Adsorption . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .70 8.5.2 Reverse Osmosis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71 8.5.3 Chemical Oxidation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73 8.5.4 Evaporation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73 8.5.5 Reed Bed Treatment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73 8.6Residuals Management . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75 8.7Life Cycle Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .75 CHAPTER 9 LANDFILL GAS MANAGEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77 9.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77 9.2 Objectives of a Landfill Gas Management System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77 9.3 Quantity of Landfill gas Generated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .77 9.4 Landfill Gas Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79 9.5 Landfill Gas Barriers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80 9.6 Landfill Gas Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80 9.7 Landfill Gas Collection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80 9.7.1 Gas Wells . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82 9.7.2 Well Heads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82 9.7.3 Collector Pipes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83 9.7.4 Condensate Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83 9.7.5 Extraction Pumps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .83 9.7.6 Commissioning / Decommissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84 9.8Utilisation of Landfill Gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84 9.9Landfill Gas Flares . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84 9.10Landfill Gas Monitoring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .85 9.11Landfill Gas Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .86 CHAPTER 10 CAPPING DESIGN & CONSTRUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 10.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 10.2 Objectives of Capping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 10.3 Capping System Design Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 10.4 Components of Capping Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 10.4.1Topsoil and Subsoil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .94 10.4.2Drainage Layer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 10.4.3Barrier Layer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 10.4.4Gas Collection Layer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 10.4.5Filter Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 10.5Recommended Capping Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 10.5.1 Hazardous Landfill Capping System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95 10.5.2 Non-Hazardous Biodegradable Landfill Capping System . . . . . . . . . . . . . . . . . . . . . . . . .96 10.5.3 Inert Landfill Capping System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 10.6Cap Stability . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 10.7 Settlement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .96 CHAPTER 11 QUALITY ASSURANCE & QUALITY CONTROL . . . . . . . . . . . . . . . . . . . . . . . .98 11.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 11.2 Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 iv LANDFILLMANUALS 11.3 Quality Assurance/Quality Control Plan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 11.3.1 Structural Organisation of a QA/QC Plan and Staffing . . . . . . . . . . . . . . . . . . . . . . . . . .98 11.3.2 Licensing Authority . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100 11.3.3 Components of a QA/QC Plan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100 11.4 Commissioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .101 CHAPTER 12 HEALTH & SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102 12.1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102 12.2 Safety,Health and Welfare at Work Act,1989 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .102 12.3 The Safety,Health and Welfare at Work (Construction Sites) Regulations,1995 . . . . . . .102 GLOSSARY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .105 REFERENCES AND FURTHER READING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .111 APPENDIX A:STORAGE BUNDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117 A.1 Bund Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .118 APPENDIX B:GROUNDWATER/SURFACE WATER MANAGEMENT . . . . . . . . . . . . . . . . . .119 B.1 Groundwater Control methods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .120 APPENDIX C:LINING SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .123 C.1 Testing of Clay Liners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124 C.1.1 Suitability Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124 C.1.2 Acceptability Testing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .124 C.2 Geomembranes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .127 C.3 Leakage Through Liners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .128 C.3.1 Calculated Rate of Leakage Per Unit Area for Various Thickness of Mineral Liner . . . . .128 C.3.2 Calculated Rate of Leakage Per Unit Area for Various Leachate Head Levels Through a 1m Thick Mineral Liner with a Hydraulic Conductivity of 1x10-9m/s . . . . . . . . . . . . .129 C.3.3 Leakage Rates Through Composite Liners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .129 APPENDIX D:LEACHATE MANAGEMENT/TREATMENT . . . . . . . . . . . . . . . . . . . . . . . . . . .132 D.1 Constituents of Inert and Hazardous Leachate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .133 D.2 Comparative Performance of Various Treatment Processes for Leachate Treatment . . . .134 D.3 Monitoring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .136 APPENDIX E:LANDFILL GAS MANAGEMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .137 LIST OF FIGURES v LIST OF FIGURES Figure 3.1: Diagrammatic Layout of a Landfill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Figure 3.2: Phasing of a Landfill Development . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8 Figure 4.1: Schematic of Typical Access,Service and Haul Roads . . . . . . . . . . . . . . . . . . . . . . . . .11 Figure 4.2: Typical Access Ramp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 Figure 4.3: Wheelcleaning Arrangements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15 Figure 4.4: Typical Civic Waste Facility Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17 Figure 5.1: Groundwater Conditions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .20 Figure 5.2: Typical Cut Off Drain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .21 Figure 5.3: Methods for Surface Water Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24 Figure 6.1(A): Lining Systems for Hazardous Waste Landfills . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27 Figure 6.1 (B): Lining Systems for Non-Hazardous and Inert Waste Landfills . . . . . . . . . . . . . . . . . . .28 Figure 6.2: Effect of Moisture Content and Compactive Energy on Hydraulic Conductivity . . for a Silty Clay (After Mitchell,Hooper and Campanella,1965) . . . . . . . . . . . . . . . . .31 Figure 6.3: Typical Anchor Trench Detail . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42 Figure 6.4: Typical Weld Details . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42 Figure 7.1: Major Stages of Waste Degradation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44 Figure 7.2: Changes in Leachate Composition (Source UK DOE 1991) . . . . . . . . . . . . . . . . . . . . .45 Figure 7.3: Relationship Between Waste Density and the Absorptive Capacity of Waste . . . . . . . . .51 Figure 7.4: Typical Leachate Collection and Removal System . . . . . . . . . . . . . . . . . . . . . . . . . . . .53 Figure 7.5: Mound Model to Determine Pipe Spacing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55 Figure 7.6: Leachate Collection Sump and Pipe Riser Going Up the Side Slope . . . . . . . . . . . . . . .57 Figure 7.7: Secondary Leak Detection Removal Systems (Hazardous Landfills Only) . . . . . . . . . .58 Figure 7.8: General Arrangement of Leachate Pumping Chamber . . . . . . . . . . . . . . . . . . . . . . . . . .59 Figure 7.9: Typical Leachate Monitoring Chamber Details . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .62 Figure 8.1: Activated Sludge Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65 Figure 8.2: Sequencing Batch Reactor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66 Figure 8.3: Rotating Biological Contactor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .67 Figure 8.4: Membrane Bioreactor System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .69 Figure 8.5: Schematic Representation of Activated Carbon Treatment System . . . . . . . . . . . . . . . .72 Figure 8.6: Reverse Osmosis Treatment System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72 Figure 8.7: Reed Bed System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .74 Figure 8.8: Leachate Treatment - Schematic of the Design Process . . . . . . . . . . . . . . . . . . . . . . . .76 Figure 9.1: Limits of Flammability of Mixtures of Methane,Air and Nitrogen . . . . . . . . . . . . . . . .78 Figure 9.2: Passive Gas Venting (Into Waste) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81 Figure 9.3: Passive Gas Control System (Venting to Atmosphere From Gas Drainage Layer) . . . . .81 Figure 9.4: Example of a Vertical Gas Well Arrangement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87 Figure 9.5: Example of Horizontal Well . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87 Figure 9.6: Example of a Hybrid Well Arrangement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88 Figure 9.7: Example of a Gabion Gas Well Arrangement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .89 Figure 9.8: Typical Well Head for Landfill Gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .89 Figure 9.9: Landfill Gas Condensate Traps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90 Figure 9.10: Typical Condensate Reservoir Complete with Syphon . . . . . . . . . . . . . . . . . . . . . . . . .90 Figure 9.11: Illustration of Landfill Gas Development & Production Options . . . . . . . . . . . . . . . . . .91 Figure 9.12: Schematic Diagram of a Landfill Gas Flare . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92 Figure 9.13: Typical Landfill Gas Monitoring Borehole (Outside Waste Body) . . . . . . . . . . . . . . . . .93 Figure 10.1: Landfill Capping Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .97 Figure 11.1: Quality Control / Assurance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99 Figure B.1: Approximate Range of Application of Groundwater Control Techniques in Soils . . . .122 Figure C.1: Calculated Rate of Leakage Per Unit Area for Various Thicknesses of Mineral Liner .128 Figure C.2: Calculated Rate of Leakage Per Unit Area for Various Heads of Leachate . . . . . . . . .129 Figure C.3: Value of I . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .131 AVG Figure C.4: Leakage Rates for Variation in Hydraulic Head and Hydraulic Conductivity for a Composite Liner With Good Contact Between Geomembrane and Soil Component . .131 vi LANDFILLMANUALS LIST OF TABLES Table 4.1: Weighbridge Types:- Advantages/Disadvantages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 Table 6.1: Soil Classification Tests . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 Table 6.2: Typical Suitable Ranges for Parameters of Clay . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 Table 6.3: Recommended Minimum Testing Frequencies for Investigation of Borrow Source . . . .34 Table 6.4 Recommended Materials Tests for Soil Liner Materials Sampled After Placement in a Loose Lift (Just Before Compaction) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34 Table 6.5: Recommended Maximum Allowance Variation for Materials Sampled After Placement in a Loose Lift (Just Before Compaction) . . . . . . . . . . . . . . . . . . . . . . . . . .34 Table 6.6: Recommended Minimum Testing Frequencies on Compacted Soil . . . . . . . . . . . . . . . .34 Table 6.7: Recommended Maximum Allowance Variation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .35 Table 6.8: Recommended Bentonite Content Test for BES Liner Materials Sampled After Placement in a Loose Lift (Just before Compaction) . . . . . . . . . . . . . . . . . . . . . . . . . . .35 Table 6.9: Geomembrane Bonding Methods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38 Table 7.1: Summary of Composition of Acetogenic Leachates Sampled from Large Landfills with a Relatively Dry High Waste Input Rate . . . . . . . . . . . . . . . . . . . . . . . . .47 Table 7.2: Summary of Composition of Methanogenic Leachates Sampled from Large Landfills with a Relatively Dry High Waste Input Rate . . . . . . . . . . . . . . . . . . . . . . . . .48 Table 7.3: Typical Water Balance Calculation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50 Table 7.4: Characteristics of Leachate that are Potential Clogging Mechanisms . . . . . . . . . . . . . .55 Table 8.1: Leachate Treatment Methods and Objectives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .64 Table 8.2: Design Criteria for Activated Sludge Plants . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .65 Table 8.3: Design Criteria for Sequencing Batch Reactor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66 Table 8.4: Design Criteria for RBC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .68 Table 8.5: Design Criteria for Powdered Activated Carbon System . . . . . . . . . . . . . . . . . . . . . . . .70 Table 9.1: Model Input Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79 Table 9.2: Monitoring Combustion Products From Flare Units . . . . . . . . . . . . . . . . . . . . . . . . . . .85 Table 11.1: Responsibilities of Those Involved in Development of a Landfill . . . . . . . . . . . . . . . .100 Table 12.1: Health,Safety and Welfare at Work (Construction Regulations) 1995 Summary of Main Duties . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .103 Table B.1: Physical Cut-Off Techniques for Exclusion of Groundwater . . . . . . . . . . . . . . . . . . . .120 Table B.2: Summary of Principal Pumped Well Groundwater Control Methods . . . . . . . . . . . . . .121 Table C.1: Advantages/Disadvantages of Basic Polymers of Geomembranes . . . . . . . . . . . . . . . .127 Table C.2: Relationship Between Liner Thickness and Rate of Leakage Per Unit Area . . . . . . . .128 Table C.3: Relationship Between Leachate Head and Rate of Leakage Per Unit Area . . . . . . . . .129 Table C.4: Leakage Rate Per Unit Area in Litre per Hectare Per Day . . . . . . . . . . . . . . . . . . . . . .130 Table D.1: Constituents of Inert and Hazardous Leachate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .133 Table D.2: Comparative Performance of Various Treatment Processes for Leachate Treatment . . .134 Table E.1: Typical Landfill Gas Composition (Source UK DOE) . . . . . . . . . . . . . . . . . . . . . . . . .138 Table E.2: Typical Instrumentation for Use with Landfill Gas . . . . . . . . . . . . . . . . . . . . . . . . . . .138